AQUA-MATE SERIES
SECTION: 2.15.035 FM2849 1015 Supersedes New
Your Peace of Mind is Our Top Priority ® ®
Product information presented here reflects conditions at time of publication. Consult factory regarding discrepancies or inconsistencies.
TECHNICAL DATA SHEET
AQUA-MATE SERIES
Model 75 Submersible Dewatering Pump Builder Series
MATERIALS
PUMP
MOTOR
PRODUCT SPECIFICATIONS Horse Power
1/2
Voltage
115
Phase
1 Ph
Hertz
60 Hz
RPM
3450
Type
Permanent split capacitor
Insulation
Class B
Amps
5.6
Operation
Automatic
Auto On/Off Points
8-1/4" (21 cm) / 2 1/2” (7 cm)
Discharge Size
1 1/2" NPT
Solids Handling
3/8" (9 mm) spherical solids
Cord Length
10' (3 m) standard
Cord Type
UL listed, 3-wire, grounded plug
Max. Head
25’ (7.6m)
Max. Flow Rate
50 GPM (189 LPM)
Max. Operating Temp.
104°F (40°C)
Cooling
Oil filled
Motor Protection
Auto reset thermal overload
Motor Housing
Cast iron
Pump Housing
Engineered plastic
Base
Engineered plastic
Upper Bearing
Ball bearing
Lower Bearing
Ball bearing
Mechanical Seals
Carbon and ceramic
Impeller Type
Non-clogging vortex
Impeller
Engineered plastic
Hardware
Stainless steel
Motor Shaft
SUS420J2 stainless steel
Gasket
NBR
2 11/16" (68.3 mm)
5 13/32" (137.3 mm) 3 15/16" (100 mm)
2 25/32" (70.6 mm)
4 1/2" (114.3 mm) 1-1/2" NPT
12 3/8" (314 mm)
2 9/16" (65.1 mm)
NOTE: See model comparison chart for specific details.
R
Certified to CSA Standard 227875
© Copyright 2015 Zoeller® Co. All rights reserved. 502-778-2731 | 800-928-7867 | 3649 Cane Run Road | Louisville, KY 40211-1961 | www.zoeller.com
SK3053
MODEL
75
Feet Meters 5 1.5 10 3.0 15 4.6 20 6.1 Shut-off Head:
Gal. Liters 50 189 40 151 30 114 17 64 25 ft. (7.6 m)
FEET
METERS
TOTAL DYNAMIC HEAD/FLOW PER MINUTE TOTAL DYNAMIC HEAD DEWATERING ONLY FLOW PER MINUTE
30
TOTAL DYNAMIC HEAD
8
6
4
25 20 15 10
FEET
2
METERS
PUMP PERFORMANCE CURVE MODEL 75
5
0
PUMP PERFORMANCE CURVE MODEL 75
GALLONS LITERS 0
10
30
40
50
60
80 160 FLOW PER MINUTE
30 25
20
153443
MODEL COMPARISON
Model M75
Seal
Mode
Volts
Ph
Amps
HP
Hz
Lbs
Kg
Single
Auto
115
1
5.6
1/2
60
16.5
7.5
20* Single piggyback switch included.
See FM0477 for a residential alternator system.
15 10 5
GALLONS LITERS 0
10
20
30
40
50
60
80 160 FLOW PER MINUTE
CAUTION
All installation of controls, protection devices and wiring should be done by a qualified licensed electrician. All electrical and safety codes should be followed including the most recent National Electrical Code (NEC) and the Occupational Safety and Health Act (OSHA).
© Copyright 2015 Zoeller® Co. All rights reserved. 502-778-2731 | 800-928-7867 | 3649 Cane Run Road | Louisville, KY 40211-1961 | www.zoeller.com
Your Peace of Mind is Our Top Priority ® ®
Product information presented here reflects conditions at time of publication. Consult factory regarding discrepancies or inconsistencies.
TECHNICAL DATA SHEET
AQUA-MATE SERIES
Model 75 Submersible Dewatering Pump Builder Series
MATERIALS
PUMP
MOTOR
PRODUCT SPECIFICATIONS Horse Power
1/2
Voltage
115
Phase
1 Ph
Hertz
60 Hz
RPM
3450
Type
Permanent split capacitor
Insulation
Class B
Amps
5.6
Operation
Automatic
Auto On/Off Points
8-1/4" (21 cm) / 2 1/2” (7 cm)
Discharge Size
1 1/2" NPT
Solids Handling
3/8" (9 mm) spherical solids
Cord Length
10' (3 m) standard
Cord Type
UL listed, 3-wire, grounded plug
Max. Head
25’ (7.6m)
Max. Flow Rate
50 GPM (189 LPM)
Max. Operating Temp.
104°F (40°C)
Cooling
Oil filled
Motor Protection
Auto reset thermal overload
Motor Housing
Cast iron
Pump Housing
Engineered plastic
Base
Engineered plastic
Upper Bearing
Ball bearing
Lower Bearing
Ball bearing
Mechanical Seals
Carbon and ceramic
Impeller Type
Non-clogging vortex
Impeller
Engineered plastic
Hardware
Stainless steel
Motor Shaft
SUS420J2 stainless steel
Gasket
NBR
2 11/16" (68.3 mm)
5 13/32" (137.3 mm) 3 15/16" (100 mm)
2 25/32" (70.6 mm)
4 1/2" (114.3 mm) 1-1/2" NPT
12 3/8" (314 mm)
2 9/16" (65.1 mm)
NOTE: See model comparison chart for specific details.
R
Certified to CSA Standard 227875
© Copyright 2015 Zoeller® Co. All rights reserved. 502-778-2731 | 800-928-7867 | 3649 Cane Run Road | Louisville, KY 40211-1961 | www.zoeller.com
SK3053
MODEL
75
Feet Meters 5 1.5 10 3.0 15 4.6 20 6.1 Shut-off Head:
Gal. Liters 50 189 40 151 30 114 17 64 25 ft. (7.6 m)
FEET
METERS
TOTAL DYNAMIC HEAD/FLOW PER MINUTE TOTAL DYNAMIC HEAD DEWATERING ONLY FLOW PER MINUTE
30
TOTAL DYNAMIC HEAD
8
6
4
25 20 15 10
FEET
2
METERS
PUMP PERFORMANCE CURVE MODEL 75
5
0
PUMP PERFORMANCE CURVE MODEL 75
GALLONS LITERS 0
10
30
40
50
60
80 160 FLOW PER MINUTE
30 25
20
153443
MODEL COMPARISON
Model M75
Seal
Mode
Volts
Ph
Amps
HP
Hz
Lbs
Kg
Single
Auto
115
1
5.6
1/2
60
16.5
7.5
20* Single piggyback switch included.
See FM0477 for a residential alternator system.
15 10 5
GALLONS LITERS 0
10
20
30
40
50
60
80 160 FLOW PER MINUTE
CAUTION
All installation of controls, protection devices and wiring should be done by a qualified licensed electrician. All electrical and safety codes should be followed including the most recent National Electrical Code (NEC) and the Occupational Safety and Health Act (OSHA).
© Copyright 2015 Zoeller® Co. All rights reserved. 502-778-2731 | 800-928-7867 | 3649 Cane Run Road | Louisville, KY 40211-1961 | www.zoeller.com
